WAGNER Paint Crew Owner's Manual download pdf (Page 3)

HAZARD: GENERAL

Can cause severe injury or property damage.

PREVENTION:

• Read all instructions and safety precautions before operating

equipment.

• Follow all appropriate local, state, and national codes governing

ventilation, fire prevention, and operation.

• The United States Government Safety Standards have been

adopted under the Occupational Safety and Health Act (OSHA).

These standards, particularly part 1910 of the General Standards

and part 1926 of the Construction Standards should be consulted.

• Use only manufacturer authorized parts. User assumes all risks

and liabilities when using parts that do not meet the minimum

specifications and safety requirements of the pump manufacturer.

• Before each use, check all hoses for cuts, leaks, abrasion or

bulging of cover. Check for damage or movement of couplings.

Immediately replace the hose if any of these conditions exist.

Never repair a paint hose. Replace it with another grounded high-

pressure hose.

• All hoses and fittings must be secured before operating spray

pump. Unsecured parts can eject at great force or leak a high

pressure fluid stream causing severe injury.

• All hoses, swivels, guns, and accessories must be pressure rated

at or above 2800 PSI/193 BAR.

• Do not spray outdoors on windy days.

• Wear clothing to keep paint off skin and hair.

• Do not operate or spray near children. Keep children away from

the equipment at all times.

• Do not overreach or stand on an unstable support. Keep effective

footing and balance at all times.

• Stay alert and watch what you are doing.

• Do not operate the unit when fatigued or under the influence of

drugs or alcohol.

Important Electrical Information

NOTICE

Use only a 3-wire extension cord that has a 3-blade grounding plug and

a 3-slot receptacle that will accept the plug on the product. Make sure

your extension cord is in good condition. When using an extension

cord, be sure to use one heavy enough to carry the current your

product will draw. An undersized cord will cause a drop in line voltage

resulting in loss of power and overheating. A 14 or 12 gauge cord is

recommended (see chart below). If an extension cord is to be used

outdoors, it must be marked with the suffix W-A after the cord type

designation. For example, a designation of SJTW-A would indicate that

the cord would be appropriate for outdoor use.

Wagner Spray Tech accessory extension cords recommended:

P/N 0090241 20 foot extension cord.

P/N 0090242 35 foot extension cord.

Do not use more than 50 feet of spray hose. If you need to

spray further than 50 feet from your power source, use more

extension cord, not more spray hose.

Cord gauge Maximum cord length

12 150 feet

14 100 feet

Grounding Instructions

This product must be grounded. In the event of an electrical short

circuit, grounding reduces the risk of electric shock by providing an

escape wire for the electric current. This product is equipped with a

cord having a grounding wire with an appropriate grounding plug. The

plug must be plugged into an outlet that is properly installed and

grounded in accordance with all local codes and ordinances.

Improper installation of the grounding plug can

result in a risk of electric shock.

If repair or replacement of the cord or plug is necessary, do not connect

the green grounding wire to either flat blade terminal. The wire with

insulation having a green outer surface with or without yellow stripes is

the grounding wire and must be connected to the grounding pin.

Check with a qualified electrician or serviceman if the grounding

instructions are not completely understood, or if you are in doubt as to

whether the product is properly grounded. Do not modify the plug

provided. If the plug will not fit the outlet, have the proper outlet

installed by a qualified electrician.

This product is for use on a nominal 120 volt circuit and has a

grounding plug that looks like the plug illustrated below. Make sure that

the product is connected to an outlet having the same configuration as

the plug.

No adapter should be used with this product.

Do not expose motor to solvents or water.

If you experience problems with your

sprayer at any time during assembly,

operation, or cleanup, please refer to

the

roubleshooting section of this

manual (page 12), or call customer

service at:

1-800-328-8251

Grounded Outlet

Grounding Pin

Cover for grounded outlet box

English

Important Safety Information • Read all safety information before

operating the equipment. Save these instructions

1 2 3 4 5 6 7 8 ... 19 20

Comments to this Manuals

No comments

WAGNER Paint Crew Owner's Manual Page 3

Comments to this Manuals

Related products and manuals for Paint Sprayer WAGNER Paint Crew